Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 1• DO NOT store or use gasoline or other fl am-mable vapors and liquids i
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0810D. Clear SpaceWARNING! DO NOT place combustible objects in front of the
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 11I. Lighting Instructions (IPI)The IPI system may be operated with two
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0812Initial Break-in Procedure• The fireplace should be run three to four ho
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 13Glass CleaningFrequency: SeasonallyBy: HomeownerTools Needed: Protecti
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0814VentingFrequency: SeasonallyBy: HomeownerTools needed: Protective glov
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 15(Either cobrahead or SIT)Figure 3.1 IPI Pilot Flame Patterns
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0816A. Typical Appliance SystemNOTICE: Illustrations and photos refl ect typ
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 17B. Design and Installation ConsiderationsHeat & Glo direct vent ga
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08185 5 Framing and Clearances A. Selecting Appliance LocationWhen selecti
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 19CBDAB. Constructing the Appliance ChaseA chase is a vertical box-like
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/082Listing Label Information/LocationModel Name: ___________________________
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0820D. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all mi
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 21Figure 6.3 Leveled Termination CapsA. Vent Termination Minimum Cleara
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0822ONPRQV= VENT TERMINALX= AIR SUPPLY INLET= AREA WHERE TERMINAL IS NOT PE
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 23A. Approved PipeThis appliance is approved for use with Hearth & Ho
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0824V1 Minimum H1 + H2 Maximum1 ft. 305 mm Cannot do1 1/2 ft. 457 mm 1-1/2 f
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 25Figure 7.5Top Vent - Horizontal Termination - (continued)Three ElbowsH
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0826Top Vent - Vertical TerminationNo ElbowFigure 7.6Note: If installing a v
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 27Figure 7.11Two ElbowsH1V1V2Three ElbowsINSTALLEDHORIZONTALLYH1H2V1V2Top
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0828A. Pipe Clearances to CombustiblesWARNING! Risk of Fire! Maintain air s
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 29A12 in.10 in.BFigure 8.6 Wall PenetrationB. Wall Penetration FramingA
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 3 Safety Alert Key:• DANGER! Indicates a hazardous situation which, if
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0830C. Install the Ceiling FirestopA ceiling fi restop MUST be used between
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 31D. Install Attic Insulation ShieldWARNING! Fire Risk. DO NOT allow loo
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0832A. Attaching Sheetrock LedgesAttach sheetrock ledges together using the
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 33C. Securing and Leveling the ApplianceWARNING! Risk of Fire! Prevent c
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/083410 10 Installing Vent Pipe A. Assemble Vent SectionsAttach Vent to t
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 35B. Assemble Slip Sections• Slide the inner fl ue of the slip section i
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0836D. Disassemble Vent Sections• Rotate either section (see Figure 10.10)
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 37E. Install Metal Roof FlashingNote: Skip this section if using the RF4
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0838G. Install RF4-8The RF4-8 may be used in place of the roof fl ashing and
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 39SCREWSCAULKSTORM COLLAR(1 of 3)Figure 10.23 Figure 10.23 TERMINATIO
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/084 = Contains updated information.13 Finishing A. Mantel and Wall Proj
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0840Figure 10.25 Venting through the wallINTERIORHEAT SHIELD OREXTENDEDHEA
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 41A. Fuel Conversion• Make sure the appliance is compatible with availab
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0842A. Wiring RequirementsNOTICE: This appliance must be electrically wired
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 43D. Electrical Service and RepairWARNING! Risk of Shock! Label all wire
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0844F. Wall Switch Installation for Fan (Optional)If the box is being wired
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 45A. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all m
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0846A. Remove Fixed Glass AssemblySee Section 14.I.B. Remove the Shipping
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 47G. Ember PlacementWARNING! Risk of Explosion! Follow ember placement i
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0848H. Install the Log AssemblySTEP 2. Place the metal grate on top of the
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 49Figure 14.19 Top ViewFigure 14.13 Top ViewSTEP 5. Log #3 (SRV2103-1
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 5B. Limited Lifetime WarrantyHearth & Home Technologies LIMITED WARR
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0850M. Air Shutter SettingAir shutter settings should be adjusted by a quali
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 5115 15 Troubleshooting With proper installation, operation, and mainten
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0852Intellifi re Ignition System - (continued)Symptom Possible Cause Correcti
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 5316 16 Reference Materials A. Appliance Dimension DiagramDimensions a
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0854B. Vent Components DiagramsFigure 16.2 DVP vent components 10-1/2 in.(
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 55DVP-TRAP1DVP-TRAP2DVP-TRAPK2DVP-TRAPK1DVP-TRAPHorizontal Termination Ca
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0856B. Vent Components Diagrams (continued)Figure 16.4 DVP vent components
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 57B. Vent Components Diagrams (continued)DVP-HRC-SSDVP-HRC-ZC-SSHORIZONT
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0858C. Service PartsPart number list on following page.Service Parts Diagram
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 59C. Service Parts List 6000GCF-IPIIMPORTANT: THIS IS DATED INFORMATION
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/086B. Limited Lifetime Warranty (continued)• This limited warranty does no
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/0860Intermittent Pilot IgnitionValve AssemblyService PartsValve Assembly Dia
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 61Heat & Glo, a brand of Hearth & Home Technologies Inc. 7571 215
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 7B. Tempered Glass Specifi cationsHearth & Home Technologies applianc
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/088H. Requirements for the Commonwealth of MassachusettsFor all side wall ho
Heat & Glo • 6000GCF-IPI, 6000GCF-IPILP • 2110-900 Rev. H • 11/08 9Figure 2.1 General Operating PartsB. Your FireplaceWARNING! DO NOT oper
Commentaires sur ces manuels